4th. Generation Chrysler Minivans: 2001-2007



ChryslerMiniVan.net is the premier Chrysler Minivan Forum on the internet. Registered Users do not see the above ads.
+ Post New Thread
Page 1 of 7 1 2 3 ... LastLast
Threads 1 to 20 of 135

Forum: 4th. Generation Chrysler Minivans: 2001-2007

Discuss your fourth generation minivan here. Get tips and technical assistance specific to your era of Chrysler Minivan

  1. Sticky Thread Sticky: What's the mileage on your 4th generation?

    Wow can't believe the van is at 180,000 Kms now.Only 20,000 kms to go until the big 200,000 kms. Seems just like yesterday I bought the van. Is their any thing that I should be on a look out for at this point? Also whats the current mileage on your 4th gen?

    Started by 04anniversaryedition, 06-06-2013 09:18 PM
    121 Pages
    1 2 3 ... 121
    • Replies: 1,208
    • Views: 179,494
    04-21-2017 07:25 AM Go to last post
  2. Sticky Thread Sticky: 02 T&C power sliding door issue

    I got a 2002 T&C Lxi, this is an intermittent problem. Sometimes the drivers side power sliding door will click open but that is it. It will not retract open. Sometimes it will work normally as well. Funny thing is is when the sliding door will not work the lift gate will act the same, pop open...

    Started by ccarbo, 01-04-2007 12:01 AM
    21 Pages
    1 2 3 ... 21
    • Replies: 207
    • Views: 176,030
    04-02-2017 11:42 PM Go to last post
  3. Sticky Thread Sticky: Owner programmable Features

    Well, after a few threads about people not knowing about features that can be programed by owners without the Electronic Vehicle Information Center (EVIC), I scanned my owners manual with the ones contained in there. Just FYI, this is out of a 2005 manual, so other years may be different. Some may...

    Started by blupupher, 03-21-2007 05:55 PM
    20 Pages
    1 2 3 ... 20
    • Replies: 194
    • Views: 205,907
    04-02-2017 11:35 PM Go to last post
  4. Sticky Thread Sticky: FYI - Chrysler acronyms - (what do those initials stand for?)

    This may help a few of you, since this has been coming up quite a lot lately. It is by no means complete, but it is a start. Here is a list that was posted on the Jeep forum by user "TheStigX" http://www.jeepforum.com/forum/f9/heres-list-chrysler-acronyms-1060854/ Here's a list of...

    Started by blknblu, 02-24-2015 10:25 AM
    2 Pages
    1 2
    • Replies: 11
    • Views: 16,942
    11-29-2016 03:35 PM Go to last post
  5. Sticky Thread Sticky: Caravan/T&C/Voyager oil filter

    I usually get my oil changed at a local dealer for $21.95 and they always seem to do a good job. (No long waits, friendly service etc.) This time I did it myself to save some time and I went to Wal-Mart to purchase my oil and filter. While looking at the four or five kinds of Fram filters they...

    Started by BuzzBob, 01-02-2006 10:12 PM
    87 Pages
    1 2 3 ... 87
    • Replies: 869
    • Views: 407,311
    08-14-2016 01:15 PM Go to last post
  1. Dear Caravan Owners: Spark Plugs Require Maintenence!

    Put your nose near the exhaust. Smell excessive gas? Ever changed your "maintenance free" platinum spark plugs? Picked up another Caravan a couple weeks ago (2003). No DTC (Check Engine light). Smells rich. Got it cheap. Fuel trims way off. Pulled out one plug. HUGE gap. Another plug - same....

    Started by markfothebeast, 04-23-2017 11:08 PM
    • Replies: 8
    • Views: 103
    04-24-2017 09:03 AM Go to last post
  2. Colliding wipers and stuck arm

    My wipers were colliding. I replaced my passenger side blade with a 22 inch (vs 28 inch) blade to solve the problem as a temp fix but even now they sometimes have issues. I have researched adjusting the alignment, but I can't figure out exactly how to take the arm off. I don't want to force...

    Started by harryman, 02-12-2017 06:11 PM
    2 Pages
    1 2
    • Replies: 10
    • Views: 1,101
    04-24-2017 08:42 AM Go to last post
  3. Whining noise getting louder!

    Hello, I have a 2007 Chrysler Town and Country with a whining noise. When I first got it about 2 years ago it had a whine and I replaced the power steering fluid and it was dramatically reduced. It has gotten back up to where it is VERY noticeable sometimes, and other times it does not demand your...

    Started by clyder, 04-18-2017 06:29 PM
    2 Pages
    1 2
    2007, noise, whine, whining
    • Replies: 17
    • Views: 552
    04-24-2017 07:37 AM Go to last post
  4. Control Arms

    Hi Everyone, Hopefully a simple question. How can I tell if my 2004 Dodge Caravan SXT has standard or heavy duty suspension? I will be replacing control arms. Thank You

    Started by Alfred13, 03-07-2017 07:50 PM
    3 Pages
    1 2 3
    • Replies: 24
    • Views: 2,151
    04-24-2017 12:42 AM Go to last post
  5. In need of instructions on replacing front and rear engine/trans mounts. 2005 3.8

    Finally got my noises and other troubles diagnoses at a shop, and it appears the very front engine mount (between the headlights), and the one of the rear closest to firewall, are worn out. It wasn't easy, but I believe I have located the correct OEM mounts, and ordered them from an out of state...

    Started by tuco05tc, 06-09-2016 12:30 PM
    • Replies: 5
    • Views: 867
    04-24-2017 12:16 AM Go to last post
  6. 2003 Voyager LX won't start - will crank

    My 2003 Voyager died Thursday. It had been running fine earlier that day. I was on my way to work, stopped to get gas, restarted the van, it ran for about 30 seconds then died. Could not restart. It has over 234k and had been intermittently throwing code P0420 until Wednesday night as I left...

    Started by nealg58, 04-14-2017 07:00 PM
    2 Pages
    1 2
    • Replies: 16
    • Views: 706
    04-23-2017 10:47 PM Go to last post
  7. Should I change transmission fluid

    I just bought a '05 T&C LX 3.3l. Runs good. I was checking things over and noticed ATF was over full a little and was really clean. I got to thinking If that fluid was recently changed who did it and what type of fluid did it get. It has 106,000 miles on it. What do you guys think? Should I do a...

    Started by adelvoyager, 08-09-2014 11:07 PM
    2 Pages
    1 2
    • Replies: 11
    • Views: 1,683
    04-23-2017 10:41 PM Go to last post
  8. alternator waterpump rythmic groaning at idle solved

    So I changed the waterpump a while back, but after there was a rythmic groaning sound that only happened at idle. I really thought it was the idler pulley so I changed that Then I thought maybe it was the serpentine tensioner I tried to isolate the sound using a bit of wood, but I couldn't...

    Started by cb250rs1, 04-23-2017 09:24 AM
    • Replies: 3
    • Views: 124
    04-23-2017 09:54 PM Go to last post
  9. Front Hitch on a 2002 Minivan

    Has anyone put a front hitch on a 2002 T&C? I'm thinking that would let me haul our bikes on the front, and then be able to put a cargo carrier on the back hitch. Any thoughts?

    Started by hobo13, 04-16-2017 10:34 AM
    3 Pages
    1 2 3
    • Replies: 20
    • Views: 682
    04-23-2017 03:21 AM Go to last post
  10. Replace Master Cylinder and Brake Booster At Same Time?

    My 2005 Town and Country van has over 250,000 miles on it. Yesterday, when I went to back it out of the driveway, I stepped on the brake pedal, heard a pop, and the brake pedal went to the floor. None of the lines going to any of the calipers are leaking. I looked near the master cylinder and...

    Started by kc27, 04-19-2017 03:29 PM
    booster, brake, cylinder, fail, master
    • Replies: 7
    • Views: 217
    04-23-2017 12:12 AM Go to last post
  11. Steering wheel stereo controls stopped working?

    Tried banging on the steering wheel. Horn works, cruise works. Have not disconnected battery or checked any fuses. Searched forums no answers. Any ideas?

    Started by wuswus73, 02-19-2017 07:22 AM
    2 Pages
    1 2
    • Replies: 16
    • Views: 1,318
    04-22-2017 11:46 PM Go to last post
  12. 2.4 to 3.8 swap

    Hello, ive tried searching and haven't found what im looking for. I have an opportunity to get an 07 dodge caravan with a blown 2.4L for basically free. What would be needed to swap in a 3.8L? New ecu, engine mounts, exhaust, what about the transmission? Axles? Any help would be great.

    Started by Andrewme, 04-20-2017 06:10 PM
    2 Pages
    1 2
    • Replies: 11
    • Views: 338
    04-22-2017 03:59 PM Go to last post
  13. I stopped and gassed up Baby II today!

    For the first time in weeks because I've been driving my new-4-me 2013 Nissan Leaf a 100% electric car! John Kuthe...

    Started by JohnKuthe, 04-20-2017 10:02 PM
    • Replies: 4
    • Views: 235
    04-22-2017 01:41 AM Go to last post
  14. Drivers side power seat?

    Hi Guys, My drivers side power seat stoped working the other day. I can tilt the seat up and down and recline the seat as well. But I can not get the seat to move forward or backwards. When I hit the button it feels like the seat wants to move either forward or backwards. But it will not move....

    Started by tekfire07, 04-22-2017 01:18 AM
    • Replies: 0
    • Views: 94
    04-22-2017 01:18 AM Go to last post
  15. Lift gate strut problem with installation

    First off thanks for the help. 2004 chrysler T&C touring got the lift supports off but then the new ones don't seem to line up if i get oone side in the other side will not line up with the screw hole it wan't to go in sideways don't want to strip anything. what am i doing wrong ? I double...

    Started by BUZAinVA, 04-21-2017 02:10 PM
    rear door lifts struts.
    • Replies: 4
    • Views: 173
    04-21-2017 09:43 PM Go to last post
  16. TPMS relearn

    Just replaced all my tires and TPMS sensors on my 05 Town & Country. Is there a way for me to get the TPMS working again without going to the dealer?

    Started by willieg, 06-20-2016 01:23 PM
    • Replies: 8
    • Views: 916
    04-21-2017 07:15 PM Go to last post
  17. New 2005 T & C owner trans fluid & filter change

    Hi! Being a technoboob, my forum search resulted in no threads. I need to know exactly what type of transmission fluid to use, suggested brand of trans filter, and how much fluid the trans takes when this service is done...I have a 2005 shorty with a 3.3...

    Started by slapshot, 04-08-2017 06:21 PM
    • Replies: 9
    • Views: 673
    04-21-2017 08:40 AM Go to last post
  18. 2001 TC engine damage

    Hi everybody. I was given a 2001 TC limited that was running badly and the owner was told the engine had a dead cylinder, and it makes a horrible clattering noise. I pulled the front three plugs and did a compression test. Two looked ok, third was dead, has significant oil contamination and slight...

    Started by kzp70, 03-30-2017 03:35 PM
    2 Pages
    1 2
    • Replies: 13
    • Views: 935
    04-20-2017 11:40 PM Go to last post
  19. Erratic Instrument Cluster

    I continue to have issues with erratic gauges on my '05. Each and every time it acts up I pull over somewhere and turn the van off and restart. This seems to get rid of the erratic cluster for several days. This has always worked for me. Other threads suggest ground wires or bad solder joints. ...

    Started by Cobrargc, 02-20-2017 07:01 PM
    2 Pages
    1 2
    • Replies: 12
    • Views: 1,374
    04-20-2017 11:25 PM Go to last post
  20. Installed a 3.8L throttle body to a 3.3L

    Checked them side by side at the bone yard, 3.8L is 20% larger, doesn't seem like it but side by side, it is quite a bit larger. Installed it. Impressions? No CEL, perfect idle, seems much more willing to move. Took it on the freeway at WOT and zero issues except for feeling like its much...

    Started by Crapavan, 03-25-2017 01:40 AM
    5 Pages
    1 2 3 ... 5
    • Replies: 41
    • Views: 2,743
    04-20-2017 01:24 PM Go to last post

+ Post New Thread

Thread Display Options

Use this control to limit the display of threads to those newer than the specified time frame.

Allows you to choose the data by which the thread list will be sorted.

Order threads in...

Note: when sorting by date, 'descending order' will show the newest results first.

Icon Legend

Contains unread posts
Contains unread posts
Contains no unread posts
Contains no unread posts
More than 15 replies or 150 views
Hot thread with unread posts
More than 15 replies or 150 views
Hot thread with no unread posts
Closed Thread
Thread is closed
Thread Contains a Message Written By You
You have posted in this thread

Posting Permissions

  • You may post new threads
  • You may post replies
  • You may not post attachments
  • You may not edit your posts