2nd Generation Chrysler Minivans: 1991-1995

ChryslerMiniVan.net is the premier Chrysler Minivan Forum on the internet. Registered Users do not see the above ads.
+ Post New Thread
Threads 1 to 14 of 14

Forum: 2nd Generation Chrysler Minivans: 1991-1995

Discuss your second generation minivan here. Get tips and technical assistance specific to your era of Chrysler Minivan

  1. sliding side door falls off track

    We just bought a 94 T&C. The side door falls off the track when you open the door all the way. It is not a power door, all manual. Is there a door stop in one of the tracks? If so, where? Is it adjustable? prone to breakage? The door doesn't fall off or anything, just a pain to get jimmied back in...

    Started by nepatternmaker, 08-23-2015 06:15 PM
    • Replies: 6
    • Views: 1,304
    01-19-2017 11:38 PM Go to last post
  2. Fuel rail leak 93 T&C 3.3

    The rail is leaking at the front left connection of the "U" tube to the injector pipe. :ask_wsign Is this a mater of replacing the rail and gaskets/O rings? Is there anything else I should consider while doing this project. An cautions or traps? Where's the best place for parts. Do I need a...

    Started by Buffalobilly, 01-08-2009 03:02 PM
    2 Pages
    1 2
    • Replies: 17
    • Views: 13,380
    01-18-2017 01:09 PM Go to last post
  3. Highway drive probs

    I have a 1992 grand caravan 3.3 drives well on city streets but after about 40 to 50 miles on highway it will shift out of overdrive (4th gear) and rwv to about 3000 rpms. If I back it down then it will shift to overdrive but if i step on accelerator a little it revs back up. Eventually doing...

    Started by CarMan095, 01-15-2017 07:01 PM
    • Replies: 0
    • Views: 76
    01-15-2017 07:01 PM Go to last post
  4. Difficulty bleeding front brakes

    Hey guys, you may recall a month or so ago I posted on here about the dragging and overheating front brakes on my mom's '94 PGV. They would self apply to the point of drastically slowing the vehicle after about 10 minutes of driving. Well, I'm starting with replacing both front flex hoses as...

    Started by MickJr, 01-08-2017 12:59 AM
    • Replies: 8
    • Views: 464
    01-13-2017 12:28 AM Go to last post
  5. 1993 Caravan 2.5L head gasket failure?

    Hi, I have multiple early 90's Dodge Caravans equipped with the 2.5 L, 4 cylinder engine coupled with the 5 speed manual transmission...I am having continual issue with head gaskets failing somewhat premature... My 1993 Caravan had the head gasket replaced in August 2012 because engine oil was...

    Started by mackeil, 01-12-2017 06:13 PM
    • Replies: 0
    • Views: 73
    01-12-2017 06:13 PM Go to last post
  6. driving light mounting on a 94

    just want to see how people mount driving lights with the standard bumper cover with no light holes.... have a set of round driving lights and was thinking of mounting them on the van for better visability at night

    Started by 94vantagegc, 01-01-2017 02:25 AM
    • Replies: 4
    • Views: 267
    01-11-2017 08:10 PM Go to last post
  7. Tranmission bust - 1995 Dodge Grand Caravan SE

    Hi everyone My transmission is bust and i'm looking to replace it with a used transmission as it's not worth buying a brand new one. I can't find any dodge grand caravans for sale as spare parts here in Whistler / Vancouver and was wondering if the same transmission is used in other vehicles...

    Started by Dodgeminivan-less, 01-06-2017 06:14 PM
    3.3l engine, dodge grand caravan, spareparts, transmission issue
    • Replies: 4
    • Views: 258
    01-07-2017 11:34 AM Go to last post
  8. AWD vacuum solenoids

    Hello, I am wondering, what are those AWD solenoids for? There is a vacuum tank near the clutch at gas tank and cables go to the rear differential. Is the differential inter-locking, then? What causes the lock to activate? I was thinking I might add a switch for it, somewhere. I do have the...

    Started by Stinovlas, 01-06-2017 12:50 PM
    • Replies: 0
    • Views: 108
    01-06-2017 12:50 PM Go to last post
  9. Engine temperature creeping up and going back down and heat not working. What to chec

    This is a 1995 Caravan equipped with a 2.5L 4-cylinder engine. It currently has approximately 124,000 miles on it. I have noticed that sometimes when driving, the coolant temperature gauge creeps up to 3/4, then goes back down to 1/2, and this might happen several times during a trip. I also...

    Started by bcohen, 11-12-2016 05:53 PM
    • Replies: 9
    • Views: 827
    01-03-2017 11:52 PM Go to last post
  10. Where is Fuse or Relay for the Trip Computer on a 1991?

    Our 1991 Plymouth Grand Voyager's trip computer stopped working some time ago. When I was doing some repairs to the overhead console I realized that the rear map lights also don't work, as map lights. They have two sets of wires run to them, and do still work when the doors are opened. I assume...

    Started by ALL41, 01-02-2017 07:19 PM
    overhead console, trip computer
    • Replies: 0
    • Views: 119
    01-02-2017 07:19 PM Go to last post
  11. Plymouth Grand Voyager wont shift out of second

    whatever the computer wanted I've done replaced all the parts of the computer want me to and it still wont shift out of 2nd any ideas

    Started by Wolfdad1971, 12-14-2016 04:09 PM
    • Replies: 8
    • Views: 486
    12-25-2016 02:32 PM Go to last post
  12. Sliding side door - Manual lock has problems unlocking *FIXED* updated DEC 2016

    Just wanted to see if anyone else has experienced difficulties with the manual locks on older vans. I've seen a lot of threads on here about the electric locks going bad but I don't have power locks. It has gotten to the point where it's a real pain to get it to unlock with the key from the...

    Started by 95plymouthvoyager, 02-01-2014 09:42 PM
    2 Pages
    1 2
    locks, side door
    • Replies: 18
    • Views: 3,991
    12-21-2016 02:29 PM Go to last post
  13. should i use a split boot to replace my 93 cracked boots

    hi, a mechanic friend said i should use a split boots to repair my 93 voyager cracked boots. any opinions? thanks, dj

    Started by dejay2012, 02-27-2014 11:24 PM
    3 Pages
    1 2 3
    • Replies: 24
    • Views: 5,230
    12-15-2016 04:06 PM Go to last post
  14. How to replace custom heater hoses/steel pipes assembly, or at least the hose portion

    This is for a 1995 Caravan 2.5L. I am doing major maintenance on my van, and want to replace all of the belts and hoses, which are very old. Fortunately, I could still buy the custom molded hoses for the radiator, but none of the other custom hoses are still available. I will be replacing the...

    Started by bcohen, 12-06-2016 10:50 PM
    • Replies: 1
    • Views: 586
    12-12-2016 07:49 PM Go to last post

+ Post New Thread

Thread Display Options

Use this control to limit the display of threads to those newer than the specified time frame.

Allows you to choose the data by which the thread list will be sorted.

Order threads in...

Note: when sorting by date, 'descending order' will show the newest results first.

Icon Legend

Contains unread posts
Contains unread posts
Contains no unread posts
Contains no unread posts
More than 15 replies or 150 views
Hot thread with unread posts
More than 15 replies or 150 views
Hot thread with no unread posts
Closed Thread
Thread is closed
Thread Contains a Message Written By You
You have posted in this thread

Posting Permissions

  • You may post new threads
  • You may post replies
  • You may not post attachments
  • You may not edit your posts